Product ID:FP-97A(M) FLUORESCENT PENETRANT (SEE SUPPL)
MSDS Date:01/01/2001
FSC:6850
NIIN:01-263-8224
Status Code:A
Kit Part:Y
MSDS Number: CLMQC

Emergency Phone: 800-424-9300

Info Phone: 310-450-1111/FAX 310452-4046

Preparer: NOT PROVIDED

Cage: 98733

Telephone: 310-450-1111/FAX 310452-4046

Cage: 98733

HYDROTREATED MIDDLE DISTILLATE

CAS: 64742-46-7

RTECS: JN9379645

OSHA PEL 5 MG/M3 (OIL MIST)

ACGIH TLV: 5 MG/M3 (OIL MIST)

LD50 LC50 Mixture:NOT PROVIDED
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:POTENTIAL HEALTH EFFECTS: EYE CONTACT:
LIQUID MAY CAUSE IRRITATION, REDNESS, TEARING AND STINGING OF EYES.
SKIN CONTACT: MAY CAUSE SKIN IRRITATION WITH PROLONGED OR REPEATED
CONTACT. SYMPTOMS MAY INCL UDE REDNESS, BURNING, AND CRACKINK OF
SKIN. SWALLOWING: SMALL AMOUNTS MAY NOT PRODUCE HARMFUL EFFECTS.
LARGE AMOUNTS MAY BE HARMFUL. INHALATION: SMALL AMOUNTS MAY NOT BE
HARMFUL. LARGE AMOUNTS MAY BE HARMFUL.
Explanation of Carcinogenicity:THIS MATERIAL IS NOT KNOWN TO CONTAIN
ANY CONSTITUENTS LISTED AS A CARCINOGEN BY THE INTERNATIONAL AGENCY
FOR RESEARCH ON CANCER, THE NATIONAL TOXICOLOGY PROGRAM , OR OSHA.
Effects of Overexposure:STOMACH OR INTESTINAL UPSET (NAUSEA, VOMITING,
DIARRHEA), IRRITATION (NOSE, THROAT, AIRWAYS), CENTRAL NERVOUS
SYSTEM DEPRESSION (DIZZINESS, DROWSINESS, FATIGUE, HEADACHE,
UNCONSCIOUSNESS).
Medical Cond Aggravated by Exposure:NOT PROVIDED

First Aid:EYES: FLUSH EYES WITH CLEAN WATER FOR AT LEAST 15 MINUTES.
HOLD EYELIDS OPEN. SEEK MEDICAL ATTENTION. SKIN: REMOVE
CONTAMINATED CLOTHING. WASH EXPOSED AREA WITH SOAP AND WATER. IF
SYMPTOMS PERSIST, SE EK MEDICAL ATTENTION. LAUNDER CLOTHING AND
CLEAN SHOES BEFORE REUSE. SWALLOWING: CALL A PHYSICIAN
IMMEDIATELY. IF INDIVIDUAL IS DROWSY OR UNCONSCIOUS, DO NOT GIVE
ANYTHING BY MOUTH; PLACE INDIVIDUAL ON THEIR LEFT SIDE WITH THE
HEAD DOWN. DO NOT LEAVE THE INDIVIDUAL UNATTENDED. INHALATION:
REMOVE TO FRESH AIR. IF NOT BREATHING, GIVE ARTIFICIAL
RESPIRATION. IF BREATHING IS DIFFICULT, GIVE OXYGEN. GET MEDICAL
ATTENTION IMMEDIATELY

Flash Point Method:PMCC
Flash Point:=93.3C, 200.F
Autoignition Temp:Autoignition Temp Text:N/AV
Lower Limits:N/AV
Upper Limits:N/AV
Extinguishing Media:DRY CHEMICAL, WATER FOG, FOAM, CARBON DIOXIDE
Fire Fighting Procedures:WATER MAY BE INEFFECTIVE. WATER SPRAY MAY BE
USED TO KEEP FIRE EXPOSED CONTAINERS COOL. WEAR FULL PROTECTIVE
CLOTHING AND NIOSH-APPROVED SELF-CONTAINED BREATHING APPARATUS WITH
FULL FACE PIECE OPERAT ED IN THE PRESSURE DEMAND OR OTHER POSITIVE
PRESSURE MODE.
Unusual Fire/Explosion Hazard:NONE KNOWN.

Spill Release Procedures:VENTILATE AREA. REMOVE ALL SOURCES OF
IGNITION. ISOLATE AREA. WEAR PROTECTIVE GEAR, KEEP UNNECESSARY
PERSONNEL AWAY. CONTAIN AND RECOVER LIQUID WHEN POSSIBLE. COLLECT
LIQUID IN AN APPROPRIATE CONTAIN ER OR ABSORB WITH AN INERT
MATERIAL SUCH AS VERMICULITE, DRY SAND, OR EARTH; DO NOT USE
COMBUSTIBLE MATERIALS, AND PLACE IN A CHEMICAL WASTE CONTAINER. DO
NOT FLUSH TO SEWER!
Neutralizing Agent:NOT RELEVANT

Handling and Storage Precautions:PROTECT AGAINST PHYSICAL DAMAGE. STORE
IN A COOL, DRY WELL-VENTILATED LOCATION, AWAY FROM AREAS WHERE FIRE
HAZARD MAY EXIST. STORE AND USE IN NO SMOKING AREA.
Other Precautions:EMPTY CONTAINERS MAY CONTAIN RESIDUE LIQUID AND
VAPORS. ANY USE OF THIS PRODUCT IN ELEVATED TEMPERATURE PROCESSING
SHOULD BE THOROUGHLY EVALUATED TO ESTABLISH AND MAINTAIN SAFE
OPERATING CONDITIONS.

Respiratory Protection:PERSONAL RESPIRATORS (NIOSH APPROVED) IF
EXPOSURE LIMIT IS EXCEEDED.
Ventilation:A SYSTEM OF LOCAL OR GENERAL EXHAUST IS RECOMMENDED TO KEEP
EMPLOYEE EXPOSURE BELOW THE AIRBORNE EXPOSURE LIMITS. LOCAL EXHAUST
VENTILATION IS PREFERRED.
Protective Gloves:WEAR RESISTANT GLOVES.
Eye Protection:CHEMICAL SPLASH GOGGLES, SAFETY GLASSES OR FULL FACE
SHIELD ARE ADVISED.
Other Protective Equipment:TO PREVENT REPEATED OR PROLONGED SKIN
CONTACT, WEAR IMPERVIOUS CLOTHING AND BOOTS. EYE WASH AND
QUICK-DRENCH FACILITIES SHOULD BE NEAR WORK AREA.
Work Hygienic Practices:NOT PROVIDED
Supplemental Safety and Health
UNIT QTY IS A KIT CONSISTING OF ONE 5 GALLON CAN OF PENETRANT AND TWO 5
GALLON CANS OF EMULSIFIER (MSDS SERIAL NUMBER: CLMPZ).

HCC:V4
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:>204.4C, 400.F
Melt/Freeze Pt:M.P/F.P Text:NOT PROVIDED
Decomp Temp:Decomp Text:NOT PROVIDED
Vapor Pres:NOT AVAILABLE
Vapor Density:N/AV
Spec Gravity:0.969
Viscosity:NOT PROVIDED
Evaporation Rate & Reference:NOT AVAILABLE
Solubility in Water:INSOLUBLE
Appearance and Odor:FLUORESCENT YELLOW-GREEN LIQUID; SLIGHT HYDROCARBON
ODOR
Percent Volatiles by Volume:NOT PROVIDED
Corrosion Rate:NOT PROVIDED

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:STABLE UNDER ORDINARY CONDITIONS OF USE
AND STORAGE.
Hazardous Decomposition Products:MAY FORM CARBON DIOXIDE AND CARBON
MONOXIDE.

Waste Disposal Methods:PROCESSING, USE OR CONTAMINATION OF THIS PRODUCT
MAY CHANGE WASTE MANAGEMENT OPTIONS. STATE AND LOCAL DISPOSAL
REGUALTIONS MAY DIFFER FROM FEDERAL DISPOSAL REGUALTIONS. DISPOSE
OF CONTAINER AND UNUSED CONTENTS IN ACCORDANCE WITH FEDERAL, STATE
AND LOCAL REQUIREMENTS.

Toxicological Information:NO DATA AVAILABLE ON PRODUCT.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

Ecological:NO DATA AVAILABLE ON PRODUCT.

Transport Information:DOT INFORMATION (49CFR 172.101): NOT REGULATED.
RQ: NOT APPLICABLE.

SARA Title III Information:SARA SECTION 302 COMPONENTS-40CFR355
APPENDIX A: NONE. SECTION 311/ 312 HAZARD CLASS-40CFR370.2:
IMMEDIATE (X), DELAYED (X), FIRE ( ), REACTIVE ( ), SUDDEN RELEASE
OF PRESSURE ( ). SARA 313 COMPONENTS -40CFR372.65: NONE.
Federal Regulatory Information:TSCA: LISTED.
State Regulatory Information:CALIFORNIA PROPOSITION 65 REQUIRES THE
FOLLOWING STATEMENT - PRODUCT MAY CONTAIN DETECTABLE AMOUNTS OF
SUBSTANCES KNOWN TO THE STATE OF CALIFORNIA TO CAUSE CANCER.